|
产品概述
Product Description
|
－一种双组分环氧重防腐蚀涂料，具有良好的附着力，优异的耐化学性和耐水性。
|
-A two pack epoxy heavy-duty anticorrosive coating and it is characterized by good adhesion and excellent resistance to chemicals, water and corrosion.
|
|
－VOC小于280g/L
|
-VOC less than 280g/L
|
|
用 途
Intended Uses
|
－用于船舶重防腐蚀区
|
-For use in heavy-duty anticorrosive areas.
|
|
－用于钢桩或混凝土码头潮差区重防腐蚀
|
-For steel or tidal range zone of concrete stakes heavy-duty anticorrosion.
|
|
－用于电厂循环水管内壁特加强级防腐
|
-For interior circulatory water piles of power plant special strengthening anticorrosion
|
|
－污水处理工程、电厂、化工厂等钢铁管内壁及混凝土结构池内壁耐酸、碱、盐、微生物等重防腐蚀
|
-For interior wall of steel pipes and concrete of Sewage treatment works, power plants and chemical plants etc. heavy-duty anticorrosion.
|
|
－自来水及水工程内防腐
|
-For works of tap water and water anticorrosion
|
|
产品信息
Product Information
|
体积固体份
Volume Solids
|
70%±2%
|
|
光泽度
Finish/Sheen
|
半光
Semi-Gloss
|
|
标准膜厚
Typical Film Thickness
|
500μm干膜厚（710μm湿膜厚）
500 microns dry (710microns wet)
|
|
理论涂布率
Theoretical Coverage
|
1.5m2/L(标准膜厚)
1.5m2/L at typical film thickness
|
|
混合比
Mix ratio
|
5:1（质量比）
5:1(mass)
|
|
施工方法
Method of Application
|
|
|
无气喷涂
Airless Spray
|
推荐使用
Recommended
|
|
|
喷嘴尺寸
Tip size range
|
0.45-0.68mm
|
|
|
出口压力
Output pressure
|
≥17MPa
|
|
空气喷涂
Air Spray
|
不推荐使用
Not recommended
|
|
刷涂/辊涂
Brush/Roller
|
适用于小面积施工
For small area only
|
|
稀释剂
Thinner
|
不推荐使用，在特殊情况下，使用HX-501（最多不超过体积总量的5%）。
Not recommended. Use HX-501 only in exceptional circumstances (volume 5%)
|
|
设备清洗剂
Cleaner
|
HX-501
|
|
熟化时间
Induction Period
|
不需要
Not necessary
|
|
干燥参数Drying Information
|
|
|
-5℃
|
5℃
|
25℃
|
35℃
|
|
表干Touch Dry
|
4h
|
2h
|
1h
|
45min
|
|
实干Hard Dry
|
48h
|
36h
|
20h
|
10h
|
|
适用期Pot Life
|
4h
|
2h
|
1h
|
40min
|
|
复涂参数Overcoating Data 底材温度Substrate Temperature
|
|
复涂下列产品时
Overcoated by
725-H45-ZF101G
|
-5℃
|
5℃
|
25℃
|
35℃
|
|
Min Max
|
Min Max
|
Min Max
|
Min Max
|
|
48h 14d
|
36h 10d
|
20h 7d
|
10h 5d
|
|
725-J43-5
|
48h 不限
|
36h 不限
|
20h 不限
|
10h 不限
|
|
贮存
Storage
|
贮存时应保持通风、干燥、防止日光直接照射，并应隔绝火源，远离热源，包装容器必须密闭。在25℃的条件下贮存期为12个月以上（应以实际检验结果为准）。
Store in cool and dry conditions. Well ventilate. Keep away from hot and fire. Shelf Life: 12 months minimum at 25℃. Subject to re-inspection thereafter
|
|
包装规格
Pack Size
|
甲组分
Part A
|
20L容器装21kg
21kg in 20L container
|
|
|
乙组分
Part B
|
5L容器装4kg/4.5L
4kg/4.5L in 5L container
|
|
闪点
Flash Point
|
甲组分
Part A
|
大于31℃
Greater than 31℃
|
|
|
乙组分
Part B
|
大于29℃
Greater than 29℃
|
|
|
混合漆
Mixed paint
|
大于31℃
Greater than 31℃
|
